PRODUCTS

  • Characteristic studies on the mechanical properties of

    2015-9-9 · quarry dust addition in conventional concrete A. Sivakumar* and Prakash M. Department of civil engineering, Vellore Institute of Technology (VIT) University, India. Accepted 1 September, 2011 Currently India has taken a major initiative on developing the infrastructures such as express highways,

    (PDF) THE EFFECT OF QUARRY DUST WITH CEMENT

    (2011) have reported that strength o f quarry dust concrete was comparably 10-12% more than of similar of conventio nal concrete. Divakar et al ., (2012) have experimented on th e

    High Performance Concrete using Quarry dust as Fine

    2016-2-29 · ABSTRACT² This paper describes the experimental study of High-Performance concrete with quarry dust as fine aggregate in addition of steel fibre. To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust

    Partial Replacement of Sand by Quarry Dust in Concrete

    2017-3-31 · investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

    (PDF) Study on Performance of Quarry Dust as Fine

    2018-3-7 · The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied. M25 grade concrete was prepared with 0%, 20%,

    USE OF QUARRY DUST IN CONCRETE AS REPLACEMENT

    2018-10-3 · construction work. Quarry dust is produced from crusher unit and each crusher unit is produced nearly 22% to 27% of dust. This dust is completely waste material for crusher unit but quarry dust is useful for construction work as sand. If we mix quarry dust in sand then only 65% to 75% of sand replaced by quarry dust because strength of concrete is

    Effect of Quarry Dust on High Performance Concrete

    2017-2-2 · 3.4 Quarry Dust The quarry dust used for this investigation work is obtained from the quarry near tindivanam in Tamil Nadu. The quarry dust passing through 4.75 mm retained on 150 micron IS sieves are taken. Specific gravity of 2.617 and fineness modulus of 2.706 has been used. 3.5 Silica Fume The specific gravity of silica fume is 2.2.

    Partial Replacement of Sand by Quarry Dust in Concrete

    Quarry dust can be defined as residue, tailing or proportions of cement concrete + quarry dust (M 20, AND M25). other non-voluble waste material after the extraction and The experimental results showed that the addition of quarry dust processing of rocks to form fine particles less than 4.75mm. as fine aggregate ratio of 30%, 40% and 50% was

    Introduction to Quarry-Dust as Partial Replacement

    2020-5-19 · The results has shown that the compressive strength of quarry dust concrete is 10-12% more along with durability under sulphate and acid action. It also shown that the water absorption property of this concrete is slightly higher and lastly they have conclude that the replacement of natural sand with quarry dust, as full replacement in concrete

    Studies on Quarry Dust as Partial Replacement of Fine

    2017-4-30 · 1. Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3. From the above results 15% replacement of quarry dust gives high Compressive and Flexural Strength. 4. By using quarry dust wastes instead of conventional

    High Performance Concrete using Quarry dust as Fine

    2016-2-29 · ABSTRACT² This paper describes the experimental study of High-Performance concrete with quarry dust as fine aggregate in addition of steel fibre. To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust

    high performance concrete using quarry dust as fine

    2014-6-1 · This paper describes the experimental study of High-Performance concrete with quarry dust as fine aggregate in addition of steel fibre. To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust is the fine material, produced from gravel crushers.

    (PDF) Modulus of rupture and surface morphology of

    2020-6-11 · sand replacement by quarry dust in the concrete mixed at 10, 20, 30 and 40 wt.% resulted in the lessening trend of flexural strength at 28 days from 11.20 to 10.60, 9.38 and 9.23 MPa respectively

    Partial Replacement of Sand by Quarry Dust in Concrete

    Quarry dust can be defined as residue, tailing or proportions of cement concrete + quarry dust (M 20, AND M25). other non-voluble waste material after the extraction and The experimental results showed that the addition of quarry dust processing of rocks to form fine particles less than 4.75mm. as fine aggregate ratio of 30%, 40% and 50% was

    PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

    2019-4-21 · addition of 25% quarry dust with cement gives the compressive strength of 41.5 N/mm2 when compared to conventional i.e. without any replacement of quarry dust. From the above test results, It is clearly observed that addition of quarry dust up to certain extent will increase the compressive strength of concrete.

    EFFECT OF REINFORCEMENT OF NATURAL RESIDUE

    2019-7-19 · wright, 2002;). Quarry dust is a by-product in the production of concrete aggregates during crushing process of rocks. Quarry dust used in concrete as fine aggregates for protecting the natural environment. About 20-25% of total production in each crusher unit is left out the quarry dust as waste material. It becomes

    Implication of Metakaolin in Quarry Dust Concrete

    2015-9-22 · initiation time of quarry dust concrete with various percentages of metakaolin have shown in Fig. 6 and Fig. 7. It is found from Fig. 6 that the time to initiate corrosion for quarry dust concrete was found to be 160 hours. Quarry dust concrete with 5%, 10%, 15% and 20% replacement of cement by metakaolin shows better

    Mechanical Properties of Fly Ash, RHA and Quarry

    2015-6-8 · Abstract. A comprehensive effort is made to partially replace the natural river sand with stone quarry dust, cement with fly ash and rice husk ash as an alternative in combination with mineral admixture for concrete ingredients which shall lead to sustainable development and lowest possible environmental impact and also reduction in the cost of construction.

    Properties of Green Concrete Mix by Concurrent use of

    2001-4-29 · the addition of fly ash is compensated by addition of quarry dust .The decrease in workability by the addition of quarry dust is reduced by the addition fly ash. This paper investigates the workability and strength characteristics of Quarry Dust Concrete (QDC) containing 0% to 30% of fly ash. Based on the test results, it can

    Effects of different industrial waste materials as partial

    2021-3-1 · Result from Fig. 4 also affirms that addition of quarry dust increased the concrete density of the with increase in quarry dust in all replacement of fine aggregate. This increase in density can be attributed to the particle size of the quarry dust which gave room to picking effect within the particle surface of the other materials in the mix.

    [PDF] Utilization of Quarry Dust in Cement Concrete

    “A study of utilization aspect of quarry dust in Indian context” Natural river sand, if replaced by hundred percent Quarry Rock Dust from quarries, maysometimes give equal or better than the reference concrete made with Natural Sand, interms of compressive and flexural strength studies The strength of Quarry Rock Dust concrete is

    High Performance Concrete using Quarry dust as Fine

    2016-2-29 · ABSTRACT² This paper describes the experimental study of High-Performance concrete with quarry dust as fine aggregate in addition of steel fibre. To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust

    high performance concrete using quarry dust as fine

    2014-6-1 · This paper describes the experimental study of High-Performance concrete with quarry dust as fine aggregate in addition of steel fibre. To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust is the fine material, produced from gravel crushers.

    IMPACT OF QUARRY DUST & DOLOMITE POWDER ON

    2018-6-20 · ABSTRACT-The purpose of this work is to describe the effect of quarry dust and dolomite on the compressive strength of concrete. The present examinations indicate that dolomite may be used as partial replacement of cement in concrete and quarry dust may be suitably replaced with fine aggregate in concrete to some extent.

    Experimental Study on Use of Quarry Dust and Fly Ash

    2020-12-19 · From the results of the experimental study, the following conclusions were drawn on concrete when quarry dust and fly ash are added in different proportions. 1) With the addition of 15% of fly ash and 15% of quarry dust the compressive strength increases to

    Utilization of Quarry Dust and Calcareous Fly Ash for the

    2020-11-25 · partial replacement of sand by quarry dust (up to 20% replacement) for the production of concrete and cement-based products improves the mechanical and durability properties, but the addition of higher quantities of quarry dust raises the water demand of the mixture.

    Implication of Metakaolin in Quarry Dust Concrete

    2015-9-22 · initiation time of quarry dust concrete with various percentages of metakaolin have shown in Fig. 6 and Fig. 7. It is found from Fig. 6 that the time to initiate corrosion for quarry dust concrete was found to be 160 hours. Quarry dust concrete with 5%, 10%, 15% and 20% replacement of cement by metakaolin shows better

    EFFECT OF REINFORCEMENT OF NATURAL RESIDUE

    2019-7-19 · wright, 2002;). Quarry dust is a by-product in the production of concrete aggregates during crushing process of rocks. Quarry dust used in concrete as fine aggregates for protecting the natural environment. About 20-25% of total production in each crusher unit is left out the quarry dust as waste material. It becomes

    Properties of Green Concrete Mix by Concurrent use of

    2001-4-29 · the addition of fly ash is compensated by addition of quarry dust .The decrease in workability by the addition of quarry dust is reduced by the addition fly ash. This paper investigates the workability and strength characteristics of Quarry Dust Concrete (QDC) containing 0% to 30% of fly ash. Based on the test results, it can

    Physico-Mechanical Properties of Concrete with Industrial

    2019-3-26 · with replacement by SSA [3]. Quarry dust was used as a partial substitute in two grades of high strength concrete (HSC) mix, 60 MPa and 70 MPa, with quarry dust quantities varying from 10% to 40%. The compressive strength obtained for both the grades of concrete was at 20% replacement, therefore the optimum percentage obtained is at 20%.

    [PDF] Utilization of Quarry Dust in Cement Concrete

    “A study of utilization aspect of quarry dust in Indian context” Natural river sand, if replaced by hundred percent Quarry Rock Dust from quarries, maysometimes give equal or better than the reference concrete made with Natural Sand, interms of compressive and flexural strength studies The strength of Quarry Rock Dust concrete is

    Review on Performance of Quarry Dust as Fine Aggregate

    2020-9-8 · nearby quarries by dumping of quarry dust and an environmental issue causing serious respiratory problems, the potential use as aggregate becomes a positive solution which is an added advantage. Many researchers in different countries studied the potential use of quarry dust in concrete. Quarry dust is

    Experimental Study on Use of Quarry Dust and Fly Ash

    2020-12-19 · From the results of the experimental study, the following conclusions were drawn on concrete when quarry dust and fly ash are added in different proportions. 1) With the addition of 15% of fly ash and 15% of quarry dust the compressive strength increases to

    IMPACT OF QUARRY DUST & DOLOMITE POWDER ON

    2018-6-20 · ABSTRACT-The purpose of this work is to describe the effect of quarry dust and dolomite on the compressive strength of concrete. The present examinations indicate that dolomite may be used as partial replacement of cement in concrete and quarry dust may be suitably replaced with fine aggregate in concrete to some extent.

    EFFECT OF REINFORCEMENT OF NATURAL RESIDUE

    2019-7-19 · wright, 2002;). Quarry dust is a by-product in the production of concrete aggregates during crushing process of rocks. Quarry dust used in concrete as fine aggregates for protecting the natural environment. About 20-25% of total production in each crusher unit is left out the quarry dust as waste material. It becomes

    Implication of Metakaolin in Quarry Dust Concrete

    2015-9-22 · initiation time of quarry dust concrete with various percentages of metakaolin have shown in Fig. 6 and Fig. 7. It is found from Fig. 6 that the time to initiate corrosion for quarry dust concrete was found to be 160 hours. Quarry dust concrete with 5%, 10%, 15% and 20% replacement of cement by metakaolin shows better

    Research Paper STRENGTH AND DURABILITY STUDIES

    2016-4-19 · The test results show that the use of well graded quarry dust instead of sand along with admixture improves the strength of concrete. Further, the addition of inhibitors provides very good resistance against chemical attack and increases corrosion resistance. KEY WORDS: concrete, quarry dust, super plasticizer,corrosion resistance

    Optimizing Concrete Mixes by Concurrent Use of Fly Ash

    2009-4-30 · workability by the addition of quarry dust is reduced by the addition of fly ash. This paper investigates quantitatively the workability and strength of a concrete mix at 3-day, 7-day, and 28-day age containing 0% 45% of fine aggregate as quarry dust and 0-30% of cementitious materials as fly ash.

    Water Absorption and Compressive Strength of Self

    2018-10-13 · quarry dust and further addition leads to the decrease the compressive strength and workability. Johnsirani, [9] has performed an experimental investigation on self-compacting concrete (SCC) with fine aggregate (sand) replacement of Quarry Dust (QD) (0%, 25%,

    Studies on quarry dust as partial replacement of fine

    2017-5-5 · Quarry dust can be used as an economic alternative to the natural sand. In this investigation an attempt is made to utilize quarry dust as a partial substitute for natural sand in producing concrete. Natural sand is replaced by Quarry dust at an interval of 5%, 10%, 15%, 20% and 25%.