PRODUCTS

  • Lead Slag an overview ScienceDirect Topics

    The use of lead slag in road construction and concrete will cause environmental risk of leaching toxic elements. The utilization rate of lead slag in cement clinker is extremely low. Geopolymers and glass-ceramics have good stabilization effect on toxic elements.

    A review on lead slag generation, characteristics, and

    2019-7-1 · The compressive strength of concrete prepared from lead slag was superior to that of ordinary concrete. In addition, concrete containing lead slag absorbed gamma radiation more, which made it different from ordinary concrete. Saikia et al. (2012, 2008) used lead slag to replace 25–35% of the fine aggregate in the preparation of the cement mortar. The strength of the cement mortar in which lead

    Utilization of secondary lead slag as construction

    Secondary lead slag, a waste product from battery smelting using CaCO3 as flux, has been investigated for its use as an admixture and/or aggregate in the production of concrete blocks. The slag was...

    EG0800309 Attenuation of Gamma Rays by Concrete

    The addition of lead slag to the concrete showed an obvious increase in density by increasing the ratio of lead slag to the total fine aggregates from 5 to 30 %, Fig. (2). This is due to the high

    LEACHING PROPERTIES OF SECONDARY LEAD SLAG

    2013-11-17 · Sodium lead slag, generated during secondary lead production, is characterized as hazardous waste. The aim of the study was to investigate leaching mechanism and behaviour of lead and arsenic from sodium lead slag previously stabilized/solidified in concrete using additives: MgO, CaO, Ba(OH)2 and gypsum. The influence of selected additives on pollutant release was also investigated.

    Application of granulated lead-zinc slag in concrete as

    2013-2-1 · Granulated slag is substituted for raw sand, partly or totally. Ratios of 25%, 50%, 75% and 100% by weight of sand are used. The effects of granulated lead-zinc slag (GLZS) as sand replacement material on the compressive strength and gamma radiation attenuation properties of concrete are investigated and analyzed.

    Suitability of Fumed Lead Blast-Furnace Slag as a

    1998-6-1 · The coulomb ratings of the concretes containing slag were lower than those obtained on equivalent control concretes but were higher than those of the fly ash concretes. The results from these preliminary tests indicate that the lead blast-furnace slag is suitable as a pozzolanic admixture

    Use of Blast Furnace Slag Aggregate in Concrete

    2016-9-9 · its suitability as a coarse aggregate in concrete making. Replacing all or some portion of natural aggregates with slag would lead to considerable environmental benefits. The results indicate that the unit weight of Blast Furnace Slag aggregate concrete is lower than that of the conventional concrete with stone chips. The

    Probing Study on Separating Pb, Zn, and Fe from Lead

    to separate Pb, Zn, and Fe from lead slag. Lead slag was mixed with coal and additive and treated in a laboratory tube furnace. In the process of direct reduction, Pb and Zn compounds were reduced to ele-mentary substances and entered into flue gas as dust. Fe was reduced to metallic iron and separated from roasted slag by magnetic separation.

    PROPERTIES AND EFFECTS OF COPPER SLAG IN CONCRETE

    2016-4-11 · copper slag the flexural strength of concrete is more than normal mix. 4. Compressive strength and flexural Strength is increased due to high toughness of copper slag. 5.As the percentage of Copper slag increases the density of concrete is increased. Density is increased by 7% due to replacement of fine aggregate at 100%. 6.

    LEACHING PROPERTIES OF SECONDARY LEAD SLAG

    2013-11-17 · Sodium lead slag, generated during secondary lead production, is characterized as hazardous waste. The aim of the study was to investigate leaching mechanism and behaviour of lead and arsenic from sodium lead slag previously stabilized/solidified in concrete using additives: MgO, CaO, Ba(OH)2 and gypsum. The influence of selected additives on

    Application of granulated lead-zinc slag in concrete as

    Granulated slag is substituted for raw sand, partly or totally. Ratios of 25%, 50%, 75% and 100% by weight of sand are used. The effects of granulated lead-zinc slag (GLZS) as sand replacement material on the compressive strength and gamma radiation attenuation properties of concrete are

    SUITABILITY OF FUMED LEAD BLAST-FURNACE SLAG

    1998-5-31 · This paper reports the findings from a laboratory evaluation of a metallurgical slag as a pozzolanic admixture for concrete. Lead blast-furnace slag is fumed in a batch process to remove base metal values after which the molten barren slag is water-quenched to produce a glassy, granular product.

    Strength and Abrasion Characteristics of ISF Slag

    Concrete specimens were prepared at different water-to-cement ratios. Compressive, flexural, and pull-off strength, along with abrasion resistance, were examined. Leaching potentials of toxic lead, zinc, and cadmium from ISF slag concrete mixtures were also analyzed to evaluate environmental viability.

    PROPERTIES AND EFFECTS OF COPPER SLAG IN CONCRETE

    2016-4-11 · increase as copper slag content increases. This will lead to an increase in the workability of concrete mixtures containing high copper slag percentages.The water absorption of coarse aggregates, sand and copper slag are shown in Table 2.7. Slag Cement Concrete: Adiabatic Strength Development

    Probing Study on Separating Pb, Zn, and Fe from Lead

    Lead slag and roasted slags were subjected to scanning electron microscopy and X-ray dif-fraction to identify the reduction mechanism of Pb, Zn, and Fe during direct reduction. concrete. Albitar et al. indicated that incorporating 75% of granulated lead smelter slag to replace fly ash as a filler can

    Use of Steel Slag in Concrete as Fine Aggregate

    2020-5-7 · conventional concrete mixture. Most of the volume of concrete is aggregates. Replacing all or some portion of natural aggregates with steel slag would lead to considerable environmental benefits. This report showcases important studies conducted on use of steel slag

    Use of Blast Furnace Slag Aggregate in Concrete IJSER

    2016-9-9 · types of concrete mixes, i.e., one comprising blast furnace slag and the other comprising granite stone as coarse aggregates. The compressive strength of BFS aggregate concrete is higher than that of the stone aggregate concrete at the age of 90 days. 1.3.Slag- Manufacturing and Types In the production of iron, iron ore, iron scrap, and fluxes

    Properties of concrete with Ground Granulated Blast

    Abstract — Ground Granulated Blast-Furnace Slag (GGBS), which is a by-product of the manufacturing of iron in the blast furnace, can partially replace cement in concrete. The use of GGBS in concrete has proved to improve certain properties, when compared to Portland cement concretes.

    Programme 7th International Slag Valorisation

    2021-4-27 · Sustainable Materials Management, VITO, 2400 Mol, Belgium Application of granulated treated lead slag as supplementary cementitious material in concrete; Michiel Giels KU Leuven Designing highly reactive precursors from bauxite residue: can the RILEM R3 test assist? Shuigen Huang

    Strength and Abrasion Characteristics of ISF Slag

    Concrete specimens were prepared at different water-to-cement ratios. Compressive, flexural, and pull-off strength, along with abrasion resistance, were examined. Leaching potentials of toxic lead, zinc, and cadmium from ISF slag concrete mixtures were also analyzed to evaluate environmental viability.

    PROPERTIES AND EFFECTS OF COPPER SLAG IN CONCRETE

    2016-4-11 · increase as copper slag content increases. This will lead to an increase in the workability of concrete mixtures containing high copper slag percentages.The water absorption of coarse aggregates, sand and copper slag are shown in Table 2.7. Slag Cement Concrete: Adiabatic Strength Development

    Probing Study on Separating Pb, Zn, and Fe from Lead

    Lead slag and roasted slags were subjected to scanning electron microscopy and X-ray dif-fraction to identify the reduction mechanism of Pb, Zn, and Fe during direct reduction. concrete. Albitar et al. indicated that incorporating 75% of granulated lead smelter slag to replace fly ash as a filler can

    Use of Steel Slag in Concrete as Fine Aggregate

    2020-5-7 · conventional concrete mixture. Most of the volume of concrete is aggregates. Replacing all or some portion of natural aggregates with steel slag would lead to considerable environmental benefits. This report showcases important studies conducted on use of steel slag

    (PDF) " Ground Granulated Blast Slag (GGBS) In

    GGBS Concrete GGBS ProportionsOn its own, ground granulated blast furnace slag (GGBS) hardens very slowly and, for use in concrete, it needs to be activated by combining it with Portland cement. A typical combination is 50% GGBS with 50% Portland cement, but percentages of GGBS [4] anywhere between 20 and 80 % are commonly used.

    Programme 7th International Slag Valorisation

    2021-4-27 · Sustainable Materials Management, VITO, 2400 Mol, Belgium Application of granulated treated lead slag as supplementary cementitious material in concrete; Michiel Giels KU Leuven Designing highly reactive precursors from bauxite residue: can the RILEM R3 test assist? Shuigen Huang

    Effect of granulated lead smelter slag on strength of fly ash

    2017-5-18 · Effect of granulated lead smelter slag on strength of fly ash-based geopolymer concrete Constru 首页 文档 视频 音频 文集 文档 搜试试 会员中心 VIP福利社 VIP免费专区 VIP专属特权 客户端 看过 登录 百度文库 行业资料 Effect of granulated lead smelter slag

    Sustainable Concrete Materials CCAA

    2018-10-11 · SCM in concrete. Slag has a coarse texture in comparison to that of portland cement, and a much slower hydration reaction. However, in the presence of activators, such as portland cement, it will behave as a hydraulic cement with characteristics similar to portland cement. The slower hydration reaction of slag means that concrete made from

    Ground Granulated Blast Furnace Slag (GGBS) and

    2016-8-11 · Hence the objective of this study is to incorporate other Pozzolanic materials in geopolymer concrete. In line with objective two Pozzolanic materials granulated blast furnace slag (GGBS) and rice husk ash (RHA) were used to replace flyash in geopolymer concrete.

    Slag Wikipedia

    2021-5-8 · Slag is the glass-like by-product left over after a desired metal has been separated (i.e., smelted) from its raw ore.Slag is usually a mixture of metal oxides and silicon dioxide.However, slags can contain metal sulfides and elemental metals. While slags are generally used to remove waste in metal smelting, they can also serve other purposes, such as assisting in the temperature control of

    concrete slag, concrete slag Suppliers and

    Blast furnace slag powder is widely used in cement and concrete; it can reduce the hydration heat of concrete, increase the later strength, and improve the microstructure of concrete, reinforcement aggregate rate of the bonding interface. 30days, 60days and 90days deferred L/C is also acceptable, the deferred L/C should be confirmed by Bank of China or other first-rate international banks.

    Making stronger concrete with 'sewage-enhanced'

    2020-4-6 · Magnified images showing concrete made with treated slag (centre), conventional aggregates (left) and raw slag (right). The treated slag forms a more seamless bond with the cement paste, making

    Method of making concrete from base metal smelter

    1995-6-26 · I claim: 1. A method of making concrete from base metal smelter slag produced by a nickel, copper, lead or zinc smelter, said slag containing (by weight) from about 15 to about 40% silica (SiO 2), from about 35 to about 60% iron oxide (Fe 2 O 3), and from about 2 to about 20% calcium oxide (CaO), comprising: . grinding the slag to a size within the range of from about -250 to about 425 mesh to

    Effect of granulated lead smelter slag on strength of fly ash

    2017-5-18 · Effect of granulated lead smelter slag on strength of fly ash-based geopolymer concrete Constru 首页 文档 视频 音频 文集 文档 搜试试 会员中心 VIP福利社 VIP免费专区 VIP专属特权 客户端 看过 登录 百度文库 行业资料 Effect of granulated lead smelter slag

    (PDF) " Ground Granulated Blast Slag (GGBS) In

    GGBS Concrete GGBS ProportionsOn its own, ground granulated blast furnace slag (GGBS) hardens very slowly and, for use in concrete, it needs to be activated by combining it with Portland cement. A typical combination is 50% GGBS with 50% Portland cement, but percentages of GGBS [4] anywhere between 20 and 80 % are commonly used.

    slag cement life cycle

    The use of slag cement to produce concrete can significantly improve the durability of concrete in several ways and consequently extends the life of concrete structures. Chemically, slag cement improves resistance to aggressive sulfate solutions and mitigates deleterious reactions between cement alkalis and reactive silica in aggregates.

    Ground Granulated Blast Furnace Slag (GGBS)

    2018-5-9 · Ground Granulated Blast Furnace Slag (GGBS) The importance of Ground Granulated Blast Furnace Slag (GGBS) lies in its greener way to become a substitute in concrete material. GGBS being a waste material, it needs proper method for disposal. So incorporating this waste material in concrete can reduce the depletion of conventional concrete components such as cement, fine aggregate and coarse

    Sustainable Concrete Materials CCAA

    2018-10-11 · SCM in concrete. Slag has a coarse texture in comparison to that of portland cement, and a much slower hydration reaction. However, in the presence of activators, such as portland cement, it will behave as a hydraulic cement with characteristics similar to portland cement. The slower hydration reaction of slag means that concrete made from

    Some smelter slags represent a significant

    Parsons has measured relatively high proportions by weight of a number of toxic elements in the Penn Mine slag: zinc levels as high as 28 percent, copper levels up to 6 percent, lead levels to 11

    Corrosion of Embedded Materials PCA

    Pozzolans and slag also increase the concrete resistivity thus reducing the corrosion rate even after it initiates. ACI 318-11, Building Code Requirements for Structural Concrete provides minimum concrete cover requirements that will help protect the embedded metals from corrosive materials. Additional measures to mitigate corrosion of steel